Jump to content

1975 Ford Granada Coupe - First 1k miles achieved


TripleRich

Recommended Posts

On 2/14/2021 at 4:49 PM, Out Run said:

Apologies if already covered, but are you EverArd Junction on YouTube @TripleRich?

 

On 2/18/2021 at 8:21 PM, TripleRich said:

Yes that's me.  I'll be doing a video on the car once I get it out on the road. 

Huh??

All this stunning work on the Granada, and then you built that railway too?

I probably shouldn't be too surprised - the attention to detail is equally fastidious, on the real thing and in miniature.

Loving the recent changes to the scrapyard scene - MOAR top work!

Link to comment
Share on other sites

  • TripleRich changed the title to 1975 Ford Granada Coupe - 1350 hours of work - On the road!
  • 4 weeks later...
1 hour ago, TripleRich said:

I wont be counting those!  I'm now in the never ending cleaning and polishing phase.  So far it's just a few dead bugs on the windscreen.  I'll stick to driving in the nicer weather.

slap some ceramic coating on it..supposed to make cleaning a piece of p*ss...

and what happened to cars...look at todays identimobiles, and then look at that Granada..Gorgeous...

would you consider throwing a 3.0 in it? or is the 2.3 there forever??

Link to comment
Share on other sites

  • 1 month later...

It's been a while!  Weather the past month was so grim and damp I left the car in the safety of the garage.  Got the car back out this weekend and did a few small jobs.

First was the exhaust rattle which was becoming very annoying.  The exhaust is an aftermarket unit and about the only one still being made for Granada's.  I had a load of fun trying to get it to fit properly when I first installed it.  The rattle is coming from both sides of the system knocking on the carrier for the propshaft centre bearing.  Not much I can do as the exhaust is just so close.  For now I've put some rubber blocks between both silencers and the floor of the car.  These force the system down by a few mm and stop the rattle.  Its far enough down the system to avoid concerns about heat but I will of course be keeping an eye on it.

Checked all the fluids etc.  Checked for any leaks and I'm well pleased it's not losing a drop of anything (so far).  

20210531_112551.thumb.jpg.170eeceff6a410c911e7a547bc92cce7.jpg

Went out for a drive and it was very well behaved, even better now the rattle has gone.  Very smooth and quiet which was just what I wanted from this car.  All that extra sound deadening seems to have really helped.  

20210530_192216.thumb.jpg.b4483fb264525879c9e0b8eb258d4d0e.jpg20210530_192222.thumb.jpg.58f6a84b29f9358615933acac619ba21.jpg

Gave it a decent workout and did about 40 miles or so.  It's a laugh in the bends, handles very well but you do feel like falling out.  I must say I'm very pleased with the XAS tyres.

One job I've been meaning to do for a while is give the vinyl roof a proper clean and remove all the paint and polish residue.  I've also attempted to waterproof it a little with various silicon based products.  There's plenty of epoxy primer on the roof but I'm not taking any chances!  

20210531_105559.thumb.jpg.372d9ea5159a15ee23914295300981e1.jpg20210531_105551.thumb.jpg.f53eecfb7e2e80c5a8375c9cd283b078.jpg

Have also booked in for FOTU.  Not too far from me and car will manage alright, should be a good trip.  Been to so many shows over the years but never had anything to show myself.  Looking forward to it.

Link to comment
Share on other sites

8 hours ago, TripleRich said:

It's been a while!  Weather the past month was so grim and damp I left the car in the safety of the garage.  Got the car back out this weekend and did a few small jobs.

First was the exhaust rattle which was becoming very annoying.  The exhaust is an aftermarket unit and about the only one still being made for Granada's.  I had a load of fun trying to get it to fit properly when I first installed it.  The rattle is coming from both sides of the system knocking on the carrier for the propshaft centre bearing.  Not much I can do as the exhaust is just so close.  For now I've put some rubber blocks between both silencers and the floor of the car.  These force the system down by a few mm and stop the rattle.  Its far enough down the system to avoid concerns about heat but I will of course be keeping an eye on it.

Checked all the fluids etc.  Checked for any leaks and I'm well pleased it's not losing a drop of anything (so far).  

20210531_112551.thumb.jpg.170eeceff6a410c911e7a547bc92cce7.jpg

Went out for a drive and it was very well behaved, even better now the rattle has gone.  Very smooth and quiet which was just what I wanted from this car.  All that extra sound deadening seems to have really helped.  

20210530_192216.thumb.jpg.b4483fb264525879c9e0b8eb258d4d0e.jpg20210530_192222.thumb.jpg.58f6a84b29f9358615933acac619ba21.jpg

Gave it a decent workout and did about 40 miles or so.  It's a laugh in the bends, handles very well but you do feel like falling out.  I must say I'm very pleased with the XAS tyres.

One job I've been meaning to do for a while is give the vinyl roof a proper clean and remove all the paint and polish residue.  I've also attempted to waterproof it a little with various silicon based products.  There's plenty of epoxy primer on the roof but I'm not taking any chances!  

20210531_105559.thumb.jpg.372d9ea5159a15ee23914295300981e1.jpg20210531_105551.thumb.jpg.f53eecfb7e2e80c5a8375c9cd283b078.jpg

Have also booked in for FOTU.  Not too far from me and car will manage alright, should be a good trip.  Been to so many shows over the years but never had anything to show myself.  Looking forward to it.

You may well walk away with the top car trophy, although it isn’t a poverty spec version of the model,  can’t remember when I last saw one

Link to comment
Share on other sites

Since the last post I've been making the most of the nice weather and using the Granada to go to work.  Been out in the evenings too and made sure to give it decent workout.

20210601_140344.thumb.jpg.a975f716c9caabb868e410dbe00216fc.jpg

I've covered another 200 miles and have been keeping a close eye on the car.  For the most part it's been excellent and a real joy to drive.  It's also slowly revealed a few small niggles which is to be expected for any car that's had a restoration.

Spend the day going through some of the niggles and giving everything underneath a good look over.  Well worth doing as you'll find stuff you didn't know about.  In my case I found a small brake fluid leak from a fitting that needed tightening a bit more.  Well worth taking the time to give things a thorough going over during your first 1000 miles of driving.

Checked over the engine and pulled the plugs.  I'm no expert when it comes to reading plugs but these certainly look happy to me.  Timing looks close too with a colour change right on the 90 degree part of the strap.

20210605_122757.thumb.jpg.2d60738957983a7f2834252ce0906f9e.jpg20210605_124654.thumb.jpg.af9381a78a6086317893734648c7f349.jpg

I also tightened the rocker covers as they were starting to weep a bit of oil.  Checked the fuel filter and changed a section of line I wasn't happy with.  Also performed various other small jobs.

A bigger job concerned the diff.  Whilst driving in 3rd or 4th gear at anywhere from 20 to 40mph there was a noticeable whine from the diff when you let off the throttle.  I decided to sort it out as it can become quite annoying once you notice it's there.

To fix I need to tighten the pinion nut a faction more.  The will increase the preload and reduce or stop the noise.  On a Granada this is a pain to get to as you have to split the diff to reach the nut.

20210605_142231.thumb.jpg.d41487fefe987845b22f81ac24c0af66.jpg

Drop the driveshaft, unbolt the diff from the beam, removed the large rear bushing bolt, remove the bolts attaching the extension housing to the diff and you can then tighten the pinion nut.

20210605_142223.thumb.jpg.da80dd38e3188b7395f88c332479ad07.jpg

I marked the position and added a touch more preload.  Put everything back together and went for a test drive.  Pleased to say 90% of the noise has been eliminated, I'll keep an eye on it but I'm happy I managed that on the first go.  It's not something you want to do twice!

20210605_144533.thumb.jpg.4fc7316bf8ea9e97b821940d773659b2.jpg

Link to comment
Share on other sites

On 6/5/2021 at 11:04 PM, High Jetter said:

Proper shakedown, following a stunning resto. If you get a sound 1,000 miles on it you can be confident everything is as it should be. Sale, or keep?

I'll certainly be keeping it for the time being.  Working on it for as long as I have got me very attached to the car.  I did consider selling if it turned out to be problematic, dull or difficult to drive.  Truth is I love driving it and would drive it every day if I could. 

Link to comment
Share on other sites

  • 1 month later...

I've done about another 300 miles since the last post.  Generally using it as a car and mostly going back and forth to work.  As the weather has been getting increasingly hot I've noticed the engine temperature creeping up a little bit each time.  

Was out for a jolly on a hot evening and the temp climbed over the 3/4 mark.  This resulted in some quite spectacular vapor lock which lead to me being stranded in the middle of nowhere!  I took the airbox off to have a look and the carb sounded like frying bacon.  All the fuel in the engine bay was either boiling or full of bubbles.

20210717_213650.thumb.jpg.844ecd05805a825cecab51917819f9e7.jpg

While the engine didn't actually overheat the fuel just couldn't handle the heat.  Modern fuel boils at lower temperatures than the old stuff.  Results are vapor lock being a much more common issue than it used to be.  Nothing I could do apart from wait hours for the car to cool.  So with it getting dark I phoned a mate and got a tow home via his trusty Rover Tomcat.  Unfortunately it was so dark I didn't take any more pictures.

I've jammed the thermostat open as a temporary measure.  Car now runs at a quarter on the gauge in 30 degree heat and seems just fine.  I've ordered a cooler stat and that should solve the problem.  One fitted was an 87 so I'll go down to an 82 and see how things go.  Apart from that I've no major issues and the car seems to be running very well.

Link to comment
Share on other sites

  • TripleRich changed the title to 1975 Ford Granada Coupe - 1350 hours of work - First FTP!
1 hour ago, TripleRich said:

I've done about another 300 miles since the last post.  Generally using it as a car and mostly going back and forth to work.  As the weather has been getting increasingly hot I've noticed the engine temperature creeping up a little bit each time.  

Was out for a jolly on a hot evening and the temp climbed over the 3/4 mark.  This resulted in some quite spectacular vapor lock which lead to me being stranded in the middle of nowhere!  I took the airbox off to have a look and the carb sounded like frying bacon.  All the fuel in the engine bay was either boiling or full of bubbles.

20210717_213650.thumb.jpg.844ecd05805a825cecab51917819f9e7.jpg

While the engine didn't actually overheat the fuel just couldn't handle the heat.  Modern fuel boils at lower temperatures than the old stuff.  Results are vapor lock being a much more common issue than it used to be.  Nothing I could do apart from wait hours for the car to cool.  So with it getting dark I phoned a mate and got a tow home via his trusty Rover Tomcat.  Unfortunately it was so dark I didn't take any more pictures.

I've jammed the thermostat open as a temporary measure.  Car now runs at a quarter on the gauge in 30 degree heat and seems just fine.  I've ordered a cooler stat and that should solve the problem.  One fitted was an 87 so I'll go down to an 82 and see how things go.  Apart from that I've no major issues and the car seems to be running very well.

Basically exactly the same as happened to me on the M1 the other day.  Thankfully being injected meant the cool down required was minutes rather than hours (reckon it was just in the lines between the distributor and injectors themselves that it had boiled).

Some foil lagging on the fuel lines will be getting added and I'm pondering an electric helper fan which I can kick on at a lower temperature than the stock one to help keep air moving.

Link to comment
Share on other sites

2 hours ago, TripleRich said:

....While the engine didn't actually overheat the fuel just couldn't handle the heat.  Modern fuel boils at lower temperatures than the old stuff.  Results are vapor lock being a much more common issue than it used to be....

Wonder if adding Tetraboost to the petrol might help?

Link to comment
Share on other sites

  • TripleRich changed the title to 1975 Ford Granada Coupe - First 1k miles achieved

Create an account or sign in to comment

You need to be a member in order to leave a comment

Create an account

Sign up for a new account in our community. It's easy!

Register a new account

Sign in

Already have an account? Sign in here.

Sign In Now
  • Similar Content

    • By 320touring
      A long time ago, in a galaxy far away, The Burd and I went to see the Skizzer to start getting a MK1 Golf Convertible that had been off the road for 10years..
      After a couple of sessions in deepest darkest Wales , coupled with some sterling help and fettling by Skizzer himself, it was time for us to head down and bring the thing back up.
       
      This went well:
      New tyres were procured and fitted

      The in-game tank pump was pulled out and a new filter fitted

       
      Then I got in touch with my Inuit side, using brand new* magnets to undertake "tank shite" fishing


      A full check over and a couple of test drives showed it fit to play.
      We set off for sunny Oswestry, only to have both front calipers sticking after 120 miles. Some water and time to collect down saw them free off and cause no further problems.
       
      Upon getting just past Tebay, it started running rough - nicking into Todhills rest area and luzzing in 10L of fuel had it running bang on for the next 70miles before it died.
      This was the final scene on the way home.

      I got to bed at 00:45, and left it to sit until today.
    • By Dave_Q
      None of my vehicles are really interesting enough for their own thread, so I'm going for a tat blog style consolidated thread.
       
      The modern* - Citroen Berlingo 2.0 HDi
       

       
      The best and only photo I have of it.
      Generally reliable but showing it's 153k miles in various areas.
      It's good at hauling people and things around, that's about all I can say.
      Current status - off road for fixing of torrential oil leak and floppy gear change.
       
      The classic* - BMW 318iS
       

       
      Photo stolen from seller's ad.
      A recent £292 ebay purchase.
      I thought I would strip it out and do some track days but after driving it for a while I'm not sure now.
      112k miles, some sort of service history, far from a creampuff but hasn't been messed about with like so many.
      Check out the orange indicators and standard 15 inch rims. SOAVE.
      Current status - daily use.
       
      Motorbike 1 - Honda VFR750
       

       
      Has done me well as a 'first big bike' but it's replacement is already lined up.
      Current status - Awoken from winter slumber and with MOT station pending results tomorrow.
       
      Motorbike 2 - Honda Fireblade
       

       
      Bought cheap as needs gearbox looking at - jumps out of second (they all do that if they've been ragged sir.)
      Current status - gearbox repair is after Berlingo on to-do list, hoping for on the road by June.
       
       
      So there they are. Not very interesting but I will update the thread with my with my various spannerings/misadventures/getting bored and selling them all etc.
    • By Zelandeth
      Well I've been meaning to sign up here in forever, but kept forgetting. Thanks to someone over on another forum I frequent poking me about it recently the subject was forced back into my very brief attention span for long enough to get me to act on the instruction.

      I figure that my little varied fleet might bring you lot some amusement...

      So...we've got:

      1993 Lada Riva 1.5E Estate (now fuel injected, as I reckon the later cars should have been from the factory...).
      1989 Saab 900i Automatic.
      1987 Skoda 120LX 21st Anniversary Special Edition.
      1985 Sinclair C5.
      2009 Peugeot 107 Verve.

      Now getting the photos together has taken me far longer than I'd expected...so you're gonna get a couple of photos of each car for now, and I'll come back with some more information tomorrow when I've got a bit more time...

      Firstly...The Lada. Before anyone asks - in response to the single question I get asked about this car: No, it is not for sale. Took me 13 years and my father's inheritance to find the thing.


      Yes, it's got the usual rusty wings...Hoping that will be resolved in the next couple of months.

       






      Next, a proper old Saab. One of the very last 8 valve cars apparently, and all the better for it. I've driven two 16v autos and they were horrible - the auto box works sooooo much better with the torque curve of the 8 valve engine. Just wish it had an overdrive for motorway cruising...









      Next up a *real* Skoda...back when they put the engine where it belongs, right out the back. In the best possible colour of course...eye-searingly bright orange.







      Seat covers have been added since that photo was taken as it suffers from the usual rotting seat cloth problem that affects virtually all Estelles.

      Then we have possibly the world's scruffiest Sinclair C5...



      Realised when looking for this that I really need to get some more photos of the thing...I use it often enough after all! We have a dog who's half husky, so this is a really good way of getting him some exercise.

      Finally - again, I really need to take more photos of - we have the little Pug 107.



      Included for the sake of variety even if it's a bit mainstream! First (and probably to be the only) new car I've bought, and has been a cracking little motor and has asked for very little in return for putting up with nearly three years of Oxford-Milton Keynes commuter traffic, before finally escaping that fate when my housemate moved to a new job. Now it doesn't do many miles and is my default car for "when I've managed to break everything else."

      I'll fill in some more details tomorrow - I warn you though that I do tend to ramble...
    • By vulgalour
      Fackin oops.
       

       
      My goal was not to buy any more cars but with the Lanchester out of action while we work through it and make it safe to use, and the Princess out of action and needing the engine to be removed (a job I am procrastinating about, and when I'm motivated am thwarted by schedule and weather conflicts) it was getting more obvious that I needed some personal transport.  Something basic and reliable that I know my way around, that's going to be cheap to buy and run.  This is an ideal candidate, on paper.
      Whether I really can just use it as An Car or will end up getting all finicky about making it nice remains to be seen.  I just want some hasslefree pootling for a few months and normally Maestros are just that.
    • By juular
      Old car - check
      Full of rust - check
      Siezed engine - check
      Cheapest on the internet - check
      Bought sight unseen - check
      No space for it - check
      Poo count - 1.5
       
×
×
  • Create New...