Jump to content
dome

Domes shonky autos-2ZZ MR2 First track day done, Exploder fettling.

Recommended Posts

Started trying to get the stink of fags out of this thing. Knackered drivers side regulator and a chain smoker=filth.

 

 

It'll need done again. And again. Still stinks inside. Any tips for getting rid of the smell of fags?

 

Will try and get the inlet manifold gasket changed this weekend and give it a coolant flush and proper bleed if I get the chance, the Locost is the priority though if I get the head back for it...

This will get rid and not mask it. Tip is to spray it on and keep it damp, it works by breaking down the stuff that causes the smell and the longer its damp the better it works.

 

http://www.cleanyourcar.co.uk/interior/carpet-fabric-cleaners/valet-pro-enzyme-odour-eater-1-litre-/prod_1054.html

Share this post


Link to post
Share on other sites

Good shout, I've just ordered some of that enzyme stuff, it'll get used on the rest of the fleet so I can justify such a purchase.

 

I do have a steam cleaner somewhere too so should be able to make it less disgusting.

Share this post


Link to post
Share on other sites

Despite a fearsome hangover today some progress has been made.

 

First mission-inlet manifold gasket

 

Engine bay seems relatively unmessed with.

 

DSC_0052_zps0krk3jmo.jpg

 

Manifold came off pretty easily.

 

Old vs new gaskets-the old one was, to use a technical term, pumped

 

DSC_0055_zpsoqngsaph.jpg

 

Cleaned up the manifold

 

DSC_0054_zpsvxvl1n7z.jpg

 

and fitted the new gasket

 

DSC_0056_zpsb4zwqqet.jpg

 

Back together and bled it up-however the thermostat seemed suspect. At this point the hangover was in full swing so I stopped taking photos and started concentrating on more important things like staying upright. Thermostat was removed-it has the later thermostat at the front of the engine bay which is a good thing. The spring clips on the hoses were a complete arse to get to.

 

Removed it and tested it-not opening. Arses. Luckily Eurocarparts near me had one in stock so I went and got a new one. Also popped into a srcappy and got a few other bits-new aerial to replace the broken one, new rear wiper to replace the broken one(there's a pattern here...) a set of genuine Land Rover rubber mats too-all for £9.60! The on to Halfords for some wiper blades(pound shop didn't have them and my trade card saved me a bit). Big spender.

 

Fitted the new thermostat and other gubbins but still struggled to get it to bleed or the radiator warm all the way through.

After a fair bit of fucking about including taking it for a drive I eventually got it to work and the fan was kicking in as it should. The coolant hoses are getting a bit hard though, although the expansion bottle was overfilled which may have contributed. I'll need to keep an eye on it.

 

I'm not convinced that I've got it in time to avoid OMGHGF yet but as it stands I'm still under £100 all in so if it needs the gasket done it'll get it.

 

Have some pics. It's only had a quick clean, it really needs a good clay/polish but it's not too bad an example.

 

DSC_0058_zpsfs2rbmkq.jpg
DSC_0059_zps2w79jcr2.jpg
DSC_0062_zps8chutrm8.jpg
DSC_0060_zpsw8jkmec7.jpg

 

Share this post


Link to post
Share on other sites

Well, Schrodingers Freelander (Until I open the bonnet the head gasket is both dead and alive) has completed the giddy heights of 100 miles since new thermostat/inlet gasket/bleed.

 

Highlights include a trip to the Scotoshite meeting where it was viewed with awe* It also got taken onto the motorway and everything at speeds of up to 70*mph.

 

The temperature gauge hasn't moved above just under halfway and it hasn't used any water. To celebrate, I'm going to spend this weekend driving an Iveco. Oh yes.  

Share this post


Link to post
Share on other sites

I've bought one of those coolant block testers to try to establish if my P6 is HGF. You're welcome to borrow it if you want to know.

I think I'll stick with the excitement* of driving it for a bit longer to see if it grenades.

 

In other news, it's leaked oil on the driveway. What does it think it is, a proper Land Rover?

Share this post


Link to post
Share on other sites

Well, now that the Locost is functioning (mostly) I suppose I'd better pay this thing some attention.

 

Today I fitted the new drivers window regulator which was pretty straightforward. I then cleaned out the idle control valve as it was idling fairly shit. It's a lot better now.

 

I then gave it it's first proper was in my charge.

 

It's Saturday night, treat yourselves to this beauty...

 

 

 

post-7629-0-94661700-1466885545_thumb.jpgpost-7629-0-04737100-1466885586_thumb.jpgpost-7629-0-64651800-1466885619_thumb.jpgpost-7629-0-47020100-1466885654_thumb.jpg

Share this post


Link to post
Share on other sites

Any tips for getting rid of the smell of fags?

 

Small bottle of UL and some matches?

 

Might be an idea to lob on a genuwine original coolant cap for the hell of it as they can be a weak spot.

 

I wonder how many of these things are still 4WD?

 

It looks pretty sound actually. Good on you for sorting it with not much pound.

Share this post


Link to post
Share on other sites

The E46 is still my daily, this is a diversion that will be getting an mot on it in a few weeks and then punted on. It's not used any water since replacing the inlet manifold gasket...

 

Good shout on the coolant cap, someone else told me the same thing. Will get one purchased.

Share this post


Link to post
Share on other sites

Those K series were unnecessarily complicated weren't they? If it had been me, I'd have launched straight into HGF repair and missed the manifold issue.

Meant to say after following you back from Armadale that it smelled okay, didn't seem to be stuff coming out of the exhaust that shouldn't have.

Share this post


Link to post
Share on other sites

Aagaadoo go grind some coffee. Presumably you put the stuff in plastic containers so it doesn't stain the damp carpets. Seem to recall reading an odd use for dog food once, but that might have been totally unrelated to a minging car interior

 

 

Sent from my iPhone using Tapatalk

Share this post


Link to post
Share on other sites

Obvs. you need to stick it on Gumtree with no mention what so ever of the shortage of driven wheels. That's what everyone does isn't it?

 

 

The usual one is 'prop shaft disconnected to make it more economical'!

Share this post


Link to post
Share on other sites

New gin-yoo-ine coolant cap is winging its way to me now. Got 5 tyres to replace the frankly shocking ones that are on it  and will have a prod about underneath it with a view to it's MOT in 3-4 weeks time. There is a random clunk, possibly the rear diff mount which is apparently cracked according to old MOTs

 

 

Those K series were unnecessarily complicated weren't they? If it had been me, I'd have launched straight into HGF repair and missed the manifold issue.
Meant to say after following you back from Armadale that it smelled okay, didn't seem to be stuff coming out of the exhaust that shouldn't have.

 

Aye that was it's first decent drive and I pushed it as hard as I dared on hard shite tyres. It went well and didn't use any water and hasn't since.

Share this post


Link to post
Share on other sites

The usual one is 'prop shaft disconnected to make it more economical'!

 

That's exactly what it said on the ad from when it was sold to the chap I got it from. It also said good tyres which is a blatant lie...

 

It does have traction control though. In reality I'm sure 95% of people who drive these things would never notice if the prop was disconnected...

Share this post


Link to post
Share on other sites

Well, some progress has been made here. I've put a few more miles on it and it was behaving itself so the dreaded MOT was undertaken.

 

And... Fail

 

Emmisions way to high, somwhere about the level of a 1960s Russian airliner. And the handbrake was sticking.

 

I bit the bullet and bought a new cat for £70 from ECP after guessing which of the two fitted it would be. Cat swapped over, new oil and filters fitted

 

I also flushed out the coolant after running a dishwasher tab through it to flush out the K Seal I'd put in when collecting it and bled it up with the correct antifreeze. These things are a collosal arse to get coolant circulating properly in and it took a while before the rad was getting hot and the fan kicking in.

 

Back in for it's test and it passed with no advisories! I got them to fit the 5 new tyres I'd accumulated at the same time so it actually goes round corners now, Nearly....

 

Its now up on Gumtree for sale or swaps. The swap ad reads

 

"May swap for other 4x4, 1980s/90s Merc or something interesting?"

 

So far I've been offered

 

A Megane Convertible

An MGF

A BMW e46 compact

An Astra Convertible

An e39 528

A Rover 25 1.4

A Citroen Picasso

AND A SPEEDBOAT!!1!!1!!!

 

 

Some of those stretch the bounds of what I deem interesting...

 

And no, I'm not going for the speedboat. What do you think this is, Bullseye? I was tempted though, for about a second.

 

Got 3 people lined up to view it over the weekend. Will they turn up? Place bets now....

Share this post


Link to post
Share on other sites

Well, some progress has been made here. I've put a few more miles on it and it was behaving itself so the dreaded MOT was undertaken.

 

And... Fail

 

Emmisions way to high, somwhere about the level of a 1960s Russian airliner. And the handbrake was sticking.

 

I bit the bullet and bought a new cat for £70 from ECP after guessing which of the two fitted it would be. Cat swapped over, new oil and filters fitted

 

I also flushed out the coolant after running a dishwasher tab through it to flush out the K Seal I'd put in when collecting it and bled it up with the correct antifreeze. These things are a collosal arse to get coolant circulating properly in and it took a while before the rad was getting hot and the fan kicking in.

 

Back in for it's test and it passed with no advisories! I got them to fit the 5 new tyres I'd accumulated at the same time so it actually goes round corners now, Nearly....

 

Its now up on Gumtree for sale or swaps. The swap ad reads

 

"May swap for other 4x4, 1980s/90s Merc or something interesting?"

 

So far I've been offered

 

A Megane Convertible

An MGF

A BMW e46 compact

An Astra Convertible

An e39 528

A Rover 25 1.4

A Citroen Picasso

AND A SPEEDBOAT!!1!!1!!!

 

 

Some of those stretch the bounds of what I deem interesting...

 

And no, I'm not going for the speedboat. What do you think this is, Bullseye? I was tempted though, for about a second.

 

Got 3 people lined up to view it over the weekend. Will they turn up? Place bets now....

Yes, so there are Bullesye winners still trying to move on their prizes.

Share this post


Link to post
Share on other sites

Swap for speedboat.

 

Remove panels on Locost.

 

Mate speedboat body with Locost chassis.

 

WIN.

I 'll just leave this here...........................[courtesy Andy Saunders....................]

 

 

 

post-2866-0-25869700-1470915887_thumb.jpg

Share this post


Link to post
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.
Note: Your post will require moderator approval before it will be visible.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

Loading...

  • Similar Content

    • By scdan4
      That bit hiding up behind the air filter and infront of the turret



      made a prolonged, loud, farty vibratey noise (loud enough to be clearly audible in the cabin with the radio on) twice today, both times it did it the nose was pointing down a steep hill and we had just parked and turned off the engine.

      It goes on for best part of a minute, so managed to track it down. Initial impressions are fuck knows what it is but it's clearly been bodged in the past. The yellow hose has clearly been disconnected sometime, by someone, for some reason, somewhere.



      Thats the blighter.

      Does someone want to tell me why it's blowing raspberries at me?


    • By Fumbler
      To mark the genesis of my fleet project thread I here present my new car: a 1997 Nissan Micra Shape-


      It really looks that good. There is a reason for this: its previous owner was an old lady who loved the thing so much so she made every effort to keep it in good shape. It originally came from Fleet in the GU postcode which suggests to me it was bought by the present dealer at auction, hence arriving down here in Kent. Before seeing the car I checked its MOT history and its only fails were thanks to broken stoplights, which shows me that it was very well cared for. I suppose an example of this was that on the last MOT, an advisory was a corroded rear silencer. The silencer on the car when I saw it was new. Methinks the lady wanted to keep it as good as possible. It was kept in a garage and so all the bumpers and black trim are very black and the tyres are in very good condition. Spare never used! Also included a free Dettol first aid kit from 1997.
      This car has 15000 genuine miles on the clock. We clocked over 15000 during the test drive! The lady owner really only trundled around her village in it and the MOT shows that it only did some meagre miles between tests. This, of course, came at a price. We saw a cherry red Micra from 2002 at the same dealer. Paint was shoddy and when they washed it the boot had massive sections of bare metal and it wasn't very happy. This car, however, is in fabulous condition and there was no contest between the two cars- it really is that good, inside and out. Immaculate interior, driver's airbag, cassette player... all there and all functioning (apart from cassette thanks to new battery and failed display). This meant that I bought it for £1600, £100 over what was my uppermost limit, but I knew I wouldn't see another like this that was in as good shape for a fair while. It was priced very ambitiously, at £1990, so I'm content in the fact I managed to slash a few hundred off the price. There wasn't that much paperwork though. All the dealership received was the logbook with 3 service stamps from 1998, 1999 and 2000, the radio key pass, a National Trust sticker, and the original paperwork holder. I suspect the old lady died and had her car auctioned, and the massive file of paperwork is now someone's egg carton, along will everything else she owned.

      As always, this car isn't exactly in showroom condition. While the inside is great and the floor is solid, and the underseal is in great shape, the not undersealed parts need a small looking at. Mainly the rear of the driver's side sill. It's really the only bubbling on the car. I suspect a well aimed stonechip managed to fester over the wintery salted roads, making it rust even more. It's around the size of a 5p piece, and will give me the opportunity to spray the insides of the sill with some chain oil to prevent any further corrosion. Behind the fuel tank there are a few rusty joints- places where the spraygun cannot get paint onto- which some Vactan and Dynax should put to rights. Alternator belt looks original because of the cracking and Nissan badges and will need doing soon as well as the front plate. As much as I like the 90's font and original dealer surround, the dishevelled R and general water ingress is a persistant MOT advisory. It could be the MOT station being strict (and most likely is considering there's a Saxo down the road with far worse blackening), however for the sake of peace of mind and all that, I'll get a new one made. The rear has already been replaced indicating this has happened before.
      All in all, I think this is a nice plucky motor. I'll have it by the end of the week; just got to sort out tax, insurance, and it's going to have an MOT. As part of the deal it's getting the MOT and an oil and filter change which will be something ticked off the list. It has some love scratches and chips here and there, but it drives well, is stiff and controllable, and should make out to be a nice summer project!
    • By dozeydustman
      Just about an hour ago I went to start my car up, had Mrs Dustman with me, to go and pick Miss Dustman up from work. Turned over fine but took a while to fire up.
       
      Steering felt heavy. Thought maybe as it's currently -5 + wind chill it's just cold & the fluid is thick.
       
      Started reversing out my bay then I was greeted with:
      "DING DONG" - ABS fault.
      "DING DONG" - ESP fault
      "DING DONG" - headlamp auto levelling not working, contact service.
       
      I shut the car down straight away and we went in Mrs D's Corolla.
       
      Alternator is less than 2 months old, it's a recon unit from Alternator Man in Portsmouth. Hoping the cold isn't killing the battery and it's taking the 'nator out with it (battery passed the drop test last time the no-charge warning came up). Looks like a session with the multimeter after work tomorrow.....
       
      MEH.
    • By clayts450
      With the recent addition of the 420 to the fleet it's high time I started a project thread devoted to all four Rovers.
       
      I've done some half-hearted attempts in the past, then done a few updates on the News 24 as and when I remembered.
       
      Today will be an intro to the fleet only with a little potted history about things wot I've done, and then I'll aim to be more blog-like in my approach to my skillful* fettling.
       
      So without further ado, welcome to the fleet.
       
      2004 Streetwise S - purchased May 2017
       

       
      It was a toss up between this and a top spec K11 Micra, but this won the day. This car marked my return behind the wheel after almost 18 years and thus was a monumental step forward for me.
       
      I'd given up driving mainly because public transport is so good in Nottingham but when my parents relocated to Newmarket from St Albans, the train journey to Suffolk was ridiculously long-winded and incorporated 55 minute waits at Cambridge to catch the connecting train to Newmarket, so enough was enough.
       
      Purchased from a shady man in East Leake ('which car ?' when I rang up) who was dealing from his front garden, this Streetwise stole my heart from day one. Annoyingly I missed out on getting it for £250 when this guy bought it and flipped it, and span a tale of a part exchange in Manchester where his old car lot had been. I wanted to call bullshit, but the price was right, £420 exchanged hands, and this came home with me.
       
      There were some issues, notably no horn nor rear fog lights (fucked Pektron BCU) but that aside, this car has wanted nothing other than consumables (tyres, exhaust, brake pads) and has never FTP (apart from user error - leaving the boot open and the dashcam on drained the battery on two occasions). The willing puppy and commutawagon, until recently this has always been my goto car, which I can always rely upon.
       
      It will continue to serve as commutawagon, not least due to its petiteness which ensures parking is easy, and its miserly fuel sipping.
       
       
×
×
  • Create New...